Honda vfr750f rc36 мануал

Brand: Honda
|
Category: Motorcycle
|
Size: 12.47 MB

• Contents

  4

• Symbols

  6

• General Information

  8

• General Safety

  8

• Carbon Monoxide

  8

• Gasoline

  8

• Coolant

  9

• Nitrogen Pressure

  9

• Battery Hydrogen Gas & Electrolyte

  9

• Model Identification

  10

• Specifications

  12

• Torque Values

  23

• Tools

  30

• Lubrication & Seal Points

  32

• Cable & Harness Routing

  36

• Emission Control Systems

  49

• Source of Emissions

  49

• Crankcase Emission Control System

  49

• Exhaust Emission Control System

  49

• Evaporative Emission Control System

  50

• Noise Emission Control System

  50

• Emission Control Information Labels

  51

• Vehicle Emission Information Label

  51

• Vehicle Emission Control Information Update Label

  51

• Vacuum Hose Routing Diagram Label

  51

• Body Panels/Exhaust System/Sub Frame Service Information

  52

• Body Panels/Exhaust System/Sub Frame Troubleshooting

  52

• Abnormal Engine Vibration

  52

• Abnormal Noise When Riding

  52

• Seat Removal

  53

• Seat Installation

  53

• Rear Fairing

  54

• Middle Fairing

  55

• Lower Fairing

  58

• Lower Center Fairing

  59

• Trim Chip Removal/Installation

  60

• Upper Fairing

  61

• Requisite Service

  61

• Sub Frame/Rear Fender

  69

• Fuel Tank

  73

• Maintenance

  76

• Service Access Guide

  77

• Maintenance Schedule

  79

• Air Cleaner

  81

• Sub Air Cleaner

  81

• Spark Plug

  82

• Valve Clearance

  82

• Shim Selection

  84

• Carburetor Synchronization

  86

• Drive Chain

  87

• Drive Chain Slack Inspection

  87

• Headlight Aim

  90

• Side Stand

  90

• Lubrication System Service Information

  92

• Lubrication System Troubleshooting

  92

• Oil Level Low

  92

• High Oil Pressure

  92

• Lubrication System Diagram

  93

• Oil Pump Removal/Installation

  94

• Oil Pump Disassembly/Assembly

  95

• Oil Cooler Removal/Installation

  96

• Cooling System Service Information

  98

• Cooling System Troubleshooting

  98

• Engine Temperature too High

  98

• Engine Temperature too Low

  98

• Cooling System Flow Pattern

  99

• Coolant Draining

  100

• Thermostat Removal/Installation

  101

• Radiator Removal/Installation

  102

• Radiator Disassembly/Assembly

  103

• Water Pump/Water Pipe Disassembly/Assembly

  104

• Fuel System Service Information

  106

• Fuel System Troubleshooting

  107

• Engine Won’t Start

  107

• Lean Mixture

  107

• Rich Mixture

  107

• Air Cleaner Housing Removal/Installation

  108

• Carburetor Removal/Installation

  109

• Fuel Tank Disassembly/Assembly

  111

• Carburetor Separation/Combination

  113

• Carburetor Tube Routing

  119

• Carburetor Disassembly/Assembly

  121

• Jet Needle Holder Removal/Installation

  125

• Carburetor Body Cleaning

  125

• Pilot Screw Adjustment

  127

• Idle Drop Procedure

  127

• High Altitude Adjustment

  129

• Secondary Air Supply System

  130

• Front Bank

  130

• Pulse Secondary Air Injection (PAIR) Control Valve

  130

• Rear Bank

  130

• Engine Removal/Installation

  132

• Engine Mounting Bolt Installation

  135

• Rear Lower Engine Mounting Bolt

  135

• Rear Upper Engine Mounting Bolt

  135

• Cylinder Head/Valves Service Information

  138

• Cylinder Head/Valves Troubleshooting

  138

• Low Compression

  138

• Excessive Smoke

  138

• Camshaft Removal

  139

• Cylinder Head, Camshaft Idle Gear Case Removal/Installation

  141

• Cylinder Head Disassembly/Assembly

  143

• Camshaft Installation

  145

• Valve Cotters Removal/Installation

  147

• Camshaft Idle Gear Case Installation

  147

• Cylinder Head Bolt Installation

  148

• When both Front and Rear Cylinder Camshafts Were Removed

  148

• Clutch System Service Information

  154

• Clutch System Troubleshooting

  154

• Clutch Lever Soft or Spongy

  154

• Clutch Slips

  154

• Right Crankcase Cover Removal/Installation

  155

• Clutch Removal

  156

• Clutch Installation

  157

• Clutch Center Lock Nut Removal

  159

• Clutch Center Lock Nut Installation

  159

• Clutch Master Cylinder Disassembly/Assembly

  160

• Clutch Slave Cylinder Disassembly/Assembly

  161

• Gearshift Linkage Service Information

  162

• Gearshift Linkage Troubleshooting

  162

• Hard to Shift

  162

• Jumps out of Gear

  162

• Drive Sprocket Cover Removal/Installation

  163

• Gearshift Linkage Removal/Installation

  165

• Crankshaft/Piston/Transmission Service Information

  168

• Crankshaft/Piston/Transmission Troubleshooting

  168

• Excessive Noise

  168

• Transmission Jumps out of Gear

  168

• Crankcase Separation

  169

• Crankshaft/Connecting Rod Removal/Installation

  171

• Piston Disassembly/Assembly

  173

• Crankshaft Bearing Replacement

  175

• Main Journal Bearing Selection

  175

• Connecting Rod Bearing Selection

  176

• Connecting Rod Selection

  176

• Transmission Removal/Installation

  177

• Mainshaft Disassembly/Assembly

  179

• Countershaft Disassembly/Assembly

  181

• Crankcase Installation

  183

• Front Wheel/Suspension/Steering Service Information

  186

• Front Wheel/Suspension/Steering Troubleshooting

  186

• Hard Steering

  186

• Soft Suspension

  186

• Right Handlebar Removal/Installation

  187

• Left Handlebar Removal/Installation

  188

• Front Wheel Removal/Installation

  189

• Front Wheel Disassembly/Assembly

  191

• Fork Removal/Installation

  193

• Fork Disassembly

  195

• Steering Stem Removal/Installation

  203

• Rear Wheel/Suspension

  206

• Rear Wheel Removal/Installation

  207

• Bearing Holder Removal/Installation

  208

• Driven Flange, Bearing Holder Disassembly/Assembly

  209

• Driven Flange Bearing Replacement

  210

• Axle Needle Bearing Replacement

  210

• Shock Absorber Removal/Installation

  211

• Lower Joint Removal/Installation

  216

• Stopper Plate Removal/Installation

  218

• Suspension Linkage Removal/Installation

  219

• Suspension Linkage Disassembly/Assembly

  220

• Cushion Rod Pivot Bearing Replacement

  223

• Shock Arm Pivot Bearing Replacement

  223

• Shock Link Bearing Replacement

  224

• Swingarm Removal/Installation

  225

• Swingarm Pivot Bolt Installation

  227

• Swingarm Disassembly/Assembly

  228

• Swingarm Pivot Bearing Replacement

  229

• Right Pivot Bearing Removal

  229

• Left Pivot Bearing Removal

  229

• Left Pivot Bearing Installation

  229

• Brakes Service Information

  232

• Brakes Troubleshooting

  232

• Brake Lever/Pedal Soft or Spongy

  232

• Brake Lever/Pedal Hard

  232

• Front Brake Pad Replacement

  233

• Rear Brake Pad Replacement

  234

• Front Master Cylinder Disassembly/Assembly

  235

• Front Brake Caliper Removal/Installation

  237

• Front Brake Caliper Disassembly/Assembly

  238

• Rear Master Cylinder Removal/Installation

  239

• Rear Master Cylinder Disassembly/Assembly

  240

• Rear Brake Caliper Removal/Installation

  241

• Rear Brake Caliper Disassembly/Assembly

  242

• Brake Pedal Removal/Installation

  243

• Charging System/Alternator

  246

• Charging System/Alternator System Location

  247

• Charging System/Alternator Circuit Diagram

  247

• Charging System/Alternator Troubleshooting

  248

• Battery Undercharging

  248

• Battery Removal/Installation

  249

• Charging System Inspection

  250

• Leak Test

  250

• Charging Voltage Inspection

  250

• Regulator/Rectifier

  251

• Wire Harness Inspection

  251

• Unit Inspection

  251

• Alternator Removal/Installation

  252

• Charging Coil Inspection

  253

• Ignition System Service Information

  254

• Ignition System Location

  255

• Ignition System Circuit Diagram

  255

• Ignition System Troubleshooting

  256

• No Spark at All Plugs

  256

• No Spark at Either Ignition Group

  257

• No Spark at One Plug

  257

• Engine Starts, but Side Stand Switch Does Not Function at All

  258

• Ignition System Inspection

  259

• Ignition Coil

  259

• Ignition Pulse Generator

  260

• Ignition Timing

  260

• Ignition Coil Removal/Installation

  261

• Ignition Pulse Generator Removal/Installation

  263

• Electric Starter/Starter Clutch Service Information

  264

• Electric Starter/Starter Clutch System Location

  265

• Electric Starter/Starter Clutch Circuit Diagram

  266

• Electric Starter/Starter Clutch Troubleshooting

  267

• Starter Motor will Not Turn

  267

• Starter Motor Turns Slowly

  269

• Starter Motor Turns, but Engine Does Not Turn

  269

• Starter Relay Switch «Clicks», but Engine Does Not Turn over

  269

• Starter Motor Removal/Installation

  270

• Starter Motor Disassembly/Assembly

  271

• Starter Clutch Removal/Installation

  273

• Starter Clutch Disassembly/Assembly

  275

• Lights/Meters/Switches

  276

• Speedometer Does Not Operate

  278

• Headlight Bulb Replacement

  280

• Headlight Removal/Installation

  281

• Turn Signal Light

  282

• Taillight

  282

• Indicator Bulb Replacement

  283

• Combination Meter Removal/Installation

  284

• Combination Meter Disassembly/Assembly

  286

• Tachometer Inspection

  289

• Ignition Switch Removal/Installation

  289

• Side Stand Switch

  290

• Fuel Level Sensor/Fuel Gauge

  290

• Low Fuel Indicator

  291

• Fuel Pump

  292

• Coolant Temperature Gauge

  292

• Thermosensor

  293

• Oil Pressure Switch

  294

• Fan Motor Switch

  294

• Diode

  295

• Neutral Switch

  295

• Headlight Relay

  295

• Headlight Does Not Shut off

  295

• High Beam Relay

  296

• Wiring Diagram

  298

• Troubleshooting

  300

• Engine Does Not Start of Is Hard to Start

  300

• Engine Lacks Power

  301

• Poor Performance at Low and Idle Speeds

  302

• Poor Performance at High Speed

  303

• Poor Handling

  303

• Index

  304

Brand: Honda
|
Category: Motorcycle
|
Size: 0.88 MB

• Important Information

  2

• Product View

  3

• Safety Messages

  6

• Contents

  7

• Motorcycle Safety

  9

• Protective Apparel

  11

• Additional Riding Gear

  12

• Loading, Accessories and Modifications

  13

• Load Limits

  14

• Loading Guidelines

  14

• Accessories and Modifications

  15

• Safety Labels

  17

• Tire Information

  18

• Parts Location

  19

• Instruments and Indicators

  22

• Description-Function

  23

• Coolant Temperature Gauge

  25

• Fuel Gauge

  26

• Digital Clock

  27

• Major Components

  28

• Suspension

  28

• Rear Suspension

  29

• Rebound Damping Adjuster

  29

• Spring Preload Adjuster

  30

• Front Brake Fluid Level

  31

• Rear Brake Fluid Level

  32

• Front Brake Lever

  33

• Other Checks

  33

• Clutch

  34

• Fluid Level

  34

• Clutch Lever

  35

• Coolant Recommendation

  36

• Inspection

  37

• Fuel Tank

  38

• Oxygenated Fuels

  40

• Engine Oil Level Check

  41

• To Check the Oil Level

  41

• Tread Wear

  44

• Tire Repair

  45

• Tire Replacement

  46

• Important Safety Reminders

  47

• Essential Individual Components Ignition Switch

  48

• Right Handlebar Controls

  49

• Engine Stop Switch

  49

• Starter Button

  49

• Left Handlebar Controls

  50

• Features

  51

• Steering Lock

  51

• Helmet Holder

  52

• Seat

  53

• Owner’s Manual Storage

  54

• Storage Compartment for U-Shaped Lock

  55

• Rear Seat Cover

  56

• Installation

  56

• Removal

  57

• Middle Fairing

  58

• Side Cover

  59

• Operation Pre-Ride Inspection

  60

• Starting the Engine

  62

• Preparation

  62

• Starting Procedure

  63

• Normal Air Temperature

  63

• High Air Temperature

  64

• Low Air Temperature

  64

• Flooded Engine

  65

• Break-In

  66

• Shifting up

  67

• Shifting down

  67

• Braking

  69

• High Altitude Running

  70

• Parking

  71

• Anti-Theft Tips

  72

• Maintenance

  73

• Maintenance Safety

  74

• Safety Precautions

  75

• Emission Requirements

  76

• Maintenance Schedule

  77

• Tool Kit

  81

• Serial Number

  82

• Colour Label

  83

• Engine Oil Recommendation

  84

• Recommended Oil Viscosity

  84

• Engine Oil and Filter

  85

• Spark Plugs

  88

• Recommended Plugs

  88

• Access to Front Cylinder Spark Plugs

  88

• Throttle Operation

  91

• Idle Speed

  92

• Coolant Replacement

  93

• Drive Chain

  94

• Drivechain

  95

• Sprockets

  95

• Wear Inspection

  97

• Lubrication and Cleaning

  98

• Brake Pad Wear

  99

• Front Brake

  99

• Rear Brake

  100

• Check the Side Stand Ignition Cut-Off System

  101

• Front Wheel Removal

  102

• Installation Notes

  104

• Rear Wheel Removal

  107

• Battery

  109

• Emergency Procedures

  110

• Battery Removal

  111

• Checking and Replacing Fuses

  112

• Fuse Box

  113

• Main Fuse

  114

• Cleaning

  115

• Aluminum Wheel Maintenance

  116

• Storage Guide

  117

• Removal from Storage

  119

• Specifications

  120

• Dimensions

  120

• Weight

  120

• Capacities

  120

• Engine

  121

• Chassis and Suspension

  122

• Power Transmission

  122

• Electrical

  123

• Lights

  123

• Fuse

  123

• Emission Control Systems

  125

• Source of Emissions

  125

• Exhaust Emission Control System

  125

• Evaporative Emission Control System

  126

• Crankcase Emission Control System

  126

• Noise Emission Control System

  126

• Among those Acts Presumed to Constitute Tampering Are the Acts Listed below

  127

• Problems that May Affect Motorcycle Emissions

  127

• Reporting Safety Defects

  129

Brand: Honda
|
Category: Motorcycle
|
Size: 19.35 MB

Brand: Honda
|
Category: Motorcycle
|
Size: 2.97 MB

• Important Notice

  4

• Contents

  7

• Motorcycle Safety

  9

• Protective Apparel

  10

• Modifications

  11

• Loading and Accessories

  12

• Parts Location

  15

• Instruments and Indicators

  18

• Coolant Temperature Gauge

  21

• Fuel Gauge

  22

• Digital Clock

  23

• Major Components

  24

• Front Suspension

  24

• Rear Suspension

  25

• Spring Preload Adjustment

  26

• Brakes

  27

• Front Brake Fluid Level

  27

• Front Brake Lever

  28

• Rear Brake Fluid Level

  29

• Clutch

  31

• Clutch Lever

  32

• Coolant Recommendation

  33

• Coolant Inspection

  34

• Fuel Tank

  35

• Petrol Containing Alcohol

  37

• Engine Oil Level Check

  38

• Tubeless Tyres

  39

• Tyre Repair/Replacement

  41

• Ignition Switch

  42

• Engine Stop Switch

  43

• Starter Button

  43

• Headlight Switch

  43

• Headlight Dimmer Switch

  44

• Passing Light Control Switch

  44

• Turn Signal Switch

  44

• Horn Button

  44

• Steering Lock

  45

• Helmet Holder

  46

• Seat/Document Bag

  47

• Storage Compartment for U-Shaped Anti-Theft Lock

  48

• Rear Seat Cover

  49

• Middle Fairing

  51

• Side Cover

  52

• Pre-Ride Inspection

  53

• Starting the Engine

  54

• Starting Procedure

  55

• Flooded Engine

  57

• Running-In

  58

• Riding

  59

• Braking

  61

• Parking

  62

• Anti-Theft Tips

  63

• Maintenance

  64

• Maintenance Schedule

  65

• Tool Kit

  68

• Serial Numbers

  69

• Colour Label

  70

• Maintenance Precautions

  70

• Engine Oil

  71

• Engine Oil and Filter

  72

• Spark Plugs

  75

• Throttle Operation

  78

• Idle Speed

  79

• Drive Chain

  80

• Drive Chain Adjustment

  82

• Wear Inspection

  83

• Lubrication and Cleaning

  83

• Drive Chain Slider

  84

• Front and Rear Suspension Inspection

  85

• Side Stand

  86

• Front Wheel Removal

  87

• Front Wheel Installation Notes

  89

• Rear Wheel Removal

  91

• Rear Wheel Installation Note

  92

• Brake Pad Wear

  93

• Front/Rear Brake

  93

• Battery

  94

• Battery Removal

  95

• Fuse Replacement

  97

• Bulb Replacement

  99

• Stop/Taillight Bulb

  101

• Front/Rear Turn Signal Bulb

  102

• Stoplight Switch Adjustment

  104

• Cleaning

  105

• Aluminum Wheel Maintenance

  106

• Storage

  107

• Removal from Storage

  109

• Specifications

  110

• Noise Control System (Australia Only)

  114

• Wiring Diagrams

  115

Brand: Honda
|
Category: Motorcycle
|
Size: 2.27 MB

Brand: Honda
|
Category: Motorcycle
|
Size: 2.24 MB